Clopay Cable & Drum Replacement Nationwide

Clopay Cable & Drum Replacement: The Las Vegas Owner’s Guide

Clopay cable and drum replacement in Las Vegas typically runs $130 – $250 installed, and we complete most swaps the same day we arrive. The cable is the steel wire that runs up each side of the door and spools onto the drum, a notched wheel mounted on the torsion bar above the opening. When either fails, the door won’t lift evenly, or it won’t lift at all. Most owners discover the problem the hard way: a loud snap, then one side of the door hanging lower than the other, sometimes with the cable wound loose around the floor or dangling from the track. It’s the kind of failure that stops your day cold, especially when the door is half-open and your car is stuck inside. We carry Clopay-compatible cables and drums on our trucks across Las Vegas, service every major Clopay residential series, and always write the price down before we touch a single bolt.

Call (725) 224-5155

Which Clopay Models This Applies To

This repair applies to the full spread of Clopay residential doors we see across Las Vegas: the Gallery and Coachman steel carriage-house lines, the Classic and Value series, and the Canyon Ridge faux-wood collection. The compatibility gotcha most owners don’t know is this: Clopay drums are not universal. Drum size and cable length are matched to the door’s height and the torsion spring’s wire size. A 7-foot door uses a different drum and shorter cable than an 8-foot door, and we’ve seen mismatched aftermarket drums chew through a new cable within months because the cable groove profile was wrong. For OEM replacement, Clopay stamps a part number on the drum and on the bottom bracket where the cable anchors. If the label is worn off, we measure the drum diameter, cable length, and cable gauge on site. Aftermarket cables made to Clopay spec are fine; the failure point is almost never the brand of steel, it’s the match to the drum and spring. We’re an independent service provider, not affiliated with Clopay, but we work on more of their doors than any other brand in Las Vegas.

Signs Your Clopay Cable & Drum Replacement Is Failing

• Door hangs crooked or jams halfway up. One cable has frayed strands that are binding inside the drum, so that side of the door lags. You’ll usually see a few broken wire strands starting to poke out near the bottom bracket.
• A visible gap between the cable and the drum. The cable should sit tight in the drum groove at all times. If it’s loose or riding up over the edge, the drum is worn or the cable has stretched beyond spec.
• You heard a loud snap, like a gunshot. That’s the cable letting go under full tension. The door may still open a few inches if the other side holds, but you’re now putting double load on one cable and the spring. Stop operating the door.
• The door slams or drops when closing. A broken cable means nothing is controlling that side of the door’s descent. The door can free-fall, and a falling 150-pound door is dangerous to people, pets, and anything under it.
• Rust flaking around the drum or bottom bracket. Las Vegas is dry, but evaporative coolers, pool equipment, or a hose bib near the garage add humidity. Rusted cables lose tensile strength and snap without much warning.

Replacement Cost & What’s Included

Cable and drum replacement in Las Vegas typically lands between $130 and $250 installed. On the lower end, a single cable swap with no drum work. On the higher end, both cables plus both drums, which is what we recommend when the drums show groove wear or the door has been run unbalanced for a while. The price always includes the parts, the labor, the re-tensioning, and a written guarantee for 365 days from the date of repair if it fails, we come back and make it right at no charge. You’ll get the number on paper before we begin, and that number does not move once work starts. We also do a quick tension check on the torsion spring while we’re there, because a spring that has lost tension is usually what killed the cable in the first place. For a door over ten years old in Las Vegas heat, we’ll tell you honestly if the spring is nearing the end of its life too.

DIY or Call Us?

Here’s the honest split. You can safely inspect: look for frayed strands, check if the cable is seated in the drum groove, and snap a photo of the drum and bottom bracket so you can describe it to us over the phone. What you should not attempt is removing or reinstalling a cable yourself. The cable is under hundreds of pounds of torque from the torsion spring. If the spring unwinds while you’re working, the drum spins and the cable whips. That’s how fingers get lost and faces get split open. Even pros treat an unbalanced door with respect; for a homeowner without a winding-bar set and years of repetitions, it’s not a weekend project. If you’re in Las Vegas and the door is stuck or unsafe, call (725) 224-5155. A real person answers, day or night, and we’ll walk you through what to do until we get there.

FAQs